北京pk拾

您好,欢迎光临山东恒能环保能源设备有限公司官网!为您提供完善的沼气生物脱硫、沼气提纯设备以及服务!欢迎来电!

北京pk拾 - 新闻资讯 >

燃气发电机启停作业注意事项大总结!

时间:2019-05-10
阅读量:
燃气发电机启停作业有很多要注意的地方,下面沼气脱硫设备厂家就给大家总结了一下,希望大家都可以认真阅读,对大家有所帮助!
Gas generator start-up and shut-down operation has a lot to pay attention to, below the methane desulfurization equipment manufacturers to summarize for you, I hope you can read carefully, to help you!
一、准备工作
I. Preparations
1、检查燃气发电机的预热系统、水循环系统是否正常;
1. Check whether the preheating system and water circulation system of gas generator are normal.
2、检查气路上各阀门的状态,检查发电机通负载电路开关状态;
2. Check the status of the valves on the gas path and the on-off status of the load circuit of the generator.
3、检查发电机组是否固定牢固,各个电线接头有无脱落。
3. Check whether the generator set is fixed firmly and whether the connection of each wire has fallen off.
4、检查机组机油,冷却水、电池液是否足够,有无渗漏;
4. Check whether the oil, cooling water and battery liquid are enough and whether there is leakage.
5、检查显示屏上电池电压,有无故障报警,若当前有故障报警,消除故障后,取消报警,否则发电机无法启动;
5. Check the battery voltage on the display screen and alarm if there is a fault. If there is a fault alarm at present, after eliminating the fault, cancel the alarm, otherwise the generator can not start.
二、操作要求
II. Operational requirements
1、熟悉发电机操作步骤,严格执行本作业指导卡;
1. Familiar with generator operation procedures, strictly implement the operation guidance card;
2、启动后必须定时观测机组工作状况。
2. The working condition of the unit must be observed regularly after start-up.
三、操作步骤
III. Operational steps
㈠ 启动燃气发电机
A Start-up Gas Generator
1、打开气路上所有阀门,调整进发电机天然气压力至15mbar(1.5KPa)左右;
燃气发电机
1. Open all valves on the gas path and adjust the natural gas pressure into the generator to about 15 bar (1.5 KPa);
2、旋转控制面板上按钮至“启动”位置,启动发电机;
2. Rotate the button on the control panel to the "start" position and start the generator.
3、机组启动后检查各参数显示是否正常(电压、频率、水温、油压等),机组各部分有无渗漏;
3. Check whether the parameters of the unit are normal (voltage, frequency, water temperature, oil pressure, etc.) and whether there is leakage in each part of the unit after start-up.
4、闭合机组输电开关,给负载供电;
4. Close the transmission switch of the unit to supply power to the load.
5、每30分钟,记录运行参数(水温、油压、电压、电流等)。
5. Record operation parameters (water temperature, oil pressure, voltage, current, etc.) every 30 minutes.
㈡ 停燃气发电机
Gas Generator with Two Stops
1、断开发电机的负载开关,使机组空载运行5分钟;
1. Disconnect the load switch of the generator to make the unit run for 5 minutes without load.
2、旋转控制面板上按钮至“停机”位置。
2. Rotate the button on the control panel to the stop position.
好了,今天的精彩内容就给大家介绍到这里了,如果大家还有疑问欢迎咨询沼气脱硫设备的官网客服人员:http://www.dh-gwsg.com
Well, today's wonderful content is introduced here. If you have any questions, please consult the official website customer service staff of biogas desulfurization equipment: http://www.dh-gwsg.com.
pk拾 pk拾 pk拾 pk拾投注 pk拾 pk拾 pk拾 pk拾 pk拾投注 北京pk拾